Votos - 3, Puntuación media: 3.7
(
)
)
|
Resumen del manual
When writing, always give the full model number which is on the nameplate attached to the inside of the cabinet door of the heater. When ordering repair parts or options, always give the following information as shown in the list: 1. The PART NUMBER 2. The PART DESCRIPTION 3. The MODEL NUMBER: 2927 4. The SERIAL NUMBER:________________ Before installing your heater, fill in the serial number of your heater in the space provided above. Owners Manual Model 2927 WONDERCOAL AUTOMATIC COAL BURNING CIRCULATOR HEATER *ASSEMBLY *INSTALLATION *OPERATION *REPAIR PARTS SAFETY NOTICE: If this heater is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and inspection requirements in your area. CAUTION: Read all instructions carefully before starting the installation or operation of this heater. Improper installation may void your warranty. DO NOT USE THIS HEATER IN A MOBILE HOME OR TRAILER United States Stove Company United States Stove Company COMPANYUNITEDSTATESSTOVECSSU P.O.Box 151 P.O.Box 151 WARNOCK HERSEY 227 Industrial Park Rd. 227 Industrial Park Rd. South Pittsburg, TN 37380 South Pittsburg, TN 37380 (423) 837-2100 (423) 837-2100 R 85761C 1/95 TOOLS AND MATERIAL NEEDED TOOLS MATERIALS Pencil 6 Foot Folding rule or tape Tin Snips Drill, hand or electric Drill bit, 1/8" dia. (for sheet metal screws) Gloves Screwdriver (blade-type) 5/16" Nut Driver or 5/16" Socket w/Ratchet Chimney Connection- 6" Dia. Black Steel (24 Ga. minimum): Straight or Elbow (as required) 1/2" Sheet Metal Screws 6" Inside Diameter Underwriters Laboratories (UL) listed Residential Type and Building Heating Appliance Chimney or lined, 6" existing Masonry Chimney. Floor Protector Material: 3' x 4'-6" as specified on page 4. Furnace Cement (Manufacturer recommends: Rutland Code 78 or Equivalent) CIRCULATOR DIMENSIONS Fig. 1 19 1/4 32 1/4 8 5/16 16 1/8 Options for Wondercoal Circulator Model 2927 F36 Blower 33 1/2 4 1/8 2 19 RULES FOR SAFE INSTALLATION AND OPERATION Read these rules and the instructions carefully. SAFETY NOTICE: If this heater is not properly installed, a house fire may result. For your safety, follow the installation directions. Contact local building or fire officials about restrictions and installation inspection requirements in your area. 31 8 9 10 11 12 38131435 7 6 4 5 3 2 133 36 15 37 16 17 18 343032 1920 21 2223 24 39 29 28 25 26 2740 4142 43 REPAIR PARTSAUTOMATIC COAL BURNING CIRCULATOR HEATERMODEL 2927 - INTERIOR 1. Check local codes. The installation must comply with their rulings. Do not install this heater in a mobile home or trailer. 2. Always connect this heater to a chimney or vent to the outside. Never vent to another room or inside a building. 3. Do not connect a COAL burning heater to an aluminum Type B gas vent. This is not safe and is prohibited by all codes. This heater requires connection to approved chimneys: Either a factor built 6" UL 103HT or a lined and approved and recently inspected and cleaned masonry chimney with a 6" flue, preferably round. A larger masonry flue may be used, so long as the flue-section diameter is not greater than 50 sq. in. The chimney portion (whether factory-built or masonry) must be tall enough to provide sufficient draft and safe exit of smoke and combustion products. Please refer to Page 5. 4. Be sure that your Chimney is safely constructed and in good repair. Have the chimney inspected by the Fire Department or a qualified inspector (such as a Chimney sweep). Your insurance company may be able to recommend a qualified inspector. 5. Inspect chimney connector and chimney twice monthly during the heating season for any deposit of creosote or soot which must be removed. 6. Provide air for combustion from outside the house into the room where the heater is located. If the intake is not in the same room, air must have free access to the room. 7. CAST IRON PARTS MUST BE "SEASONED" TO AVOID CRACKING. BUILD ONLY SMALL FIRES ON FIRST USE. 8. To prevent injury, do not allow anyone to use this heater who is unfamiliar with the correct operation of the heater. Do not allow children to use or in any way operate this heater. CAUTION: DO NOT TOUCH THE HEATER UNTIL IT HAS COOLED. ALWAYS WEAR GLOVES WHEN REFUELING THIS UNIT OR WORKING WITH METAL CABINET PARTS. 18 3 9. For further information on using your heater safely, obtain a copy of the National Fire Protection Association (NFPA) publication "Using Coal and Wood Stoves Safely" NFPA No. HS-10-1978. The address of the NFPA is Battery March Park, Quincy, MA. 02269. 10. Keep the ash pit section free of excess ashes. Do not allow ashes to stack higher than the sides of the ash pan. 11. DISPOSAL OF ASHES- Ashes should be placed in a metal container with a tight fitting lid. Keep the closed container on a non-combustible floor or on the ground, well away from all combustible materials. Keep the ashes in the closed container until all...