Votos - , Puntuación media:
(
)
)
Fabricar: Prince Castle
Tamaño del archivo: 3.1 mb
Nombre del archivo: f4082f29-1e3d-47d9-862e-3919c35e0040.pdf
Idioma del manual:
El documento se está cargando, por favor, espere
 |
El documento se está cargando, por favor, espere
Resumen del manual
LIMITED WARRANTY This product is warranted to be free from defects in material and/or workmanship for a period of one (1) year from date of original installation, not to exceed 30 months from date of shipment from our factory. Any component which proves to be faulty in material and/or workmanship will be replaced or repaired (at the option of Prince Castle, Inc.) without cost to the customer for parts or labor. This warranty covers on location service (i.e., trip charges and/or mileage). Travel mileage is limited to 100 miles (200 kilometers) round trip (one trip warranty) from an authorized service agency or its sub-service agency. This warranty is subject to the following exceptions/conditions: Use of any non-genuine Prince Castle parts voids this warranty. All labor shall be performed during regular work hours. Overtime premium will be charged to the buyer. Damage caused by carelessness, neglect, and/or abuse (e.g., dropping, tampering or altering parts, equipment damaged in shipment, by fire, flood or an act of God) is not covered under this warranty. TABLE OF CONTENTS SPECIFICATIONS Power Voltage.........................................................................240 VAC Power Amps...........................................................................27 Amps Phase...................................................................................................3 Frequency...............................................................................50/60 Hz Boiler Controller Power............................................................24VAC Control Power...........................................................................24 VAC Max Pressure............................................................................100 PSI Working Pressure......................................................................80 PSI 355 East Kehoe Blvd. • Carol Stream, IL 60118 Phone: 630-462-8800 • Toll Free: 1-800-PCASTLE Fax: 630-462-1460 • Product Identification...........................................1Safety Information...............................................2Important!...........................................................2Installation.........................................................2General Preparation & Operation...........................3Cooking Pasta.....................................................7Periodic Maintenance & Cleaning...........................7 Safety Information Important! WARNING! Indicates information important to the proper operation of the unit. Failure to observe may result in damage to the equipment and/or severe bodily injury or death. CAUTION! Indicates information important to the operation of the unit. Failure to observe may result in damage to the equipment. Prince Castle reserves the right to change specifications and product design without notice. Such revisions do not entitle the buyer to corresponding changes, improvements, additions or replacements for previously purchased equipment. Installation Pre-Installation General Setup Pre-installation is the responsibility of the user and should be completed prior to the shipment of the unit to the location. Floor drain sink located no further than 10 ft. from the intended location of the unit. Electrical hookup box located no further than 5 ft. from the intended location of the unit. The box should provide three phase, 240 V protected with a three-phase 30-A breaker. All terminals should be rated for gauge number 10-4 wire (L1-L2- L3-Ground). Dedicated water outlet with manual shut off valve no further than 7 ft. from the intended location of the unit. The water pressure should be at least 50 psi. The manual shut-off valve output has to accommodate . in. NPT Hose connector. Supporting counter with the minimum suggested dimensions of 24 in. high, 28 in. deep, and 44 in. wide. The counter must be capable of withstanding 340 lbs (weight of unit). This unit is completely pre-wired and thoroughly tested prior to shipment. All wiring and hookups shall be done without opening the unit. Place unit on the counter. The counter must be designed to fit the size and support the weight of the unit. The unit must be level to insure proper function. To level the unit, use only the adjustable leveling feet (no shims or foreign objects). EPH require a minimum height of 4 in. between the counter and the unit. Plumbing Connections It is highly recommended that a licensed plumber install all plumbing connections. All pre-installation and installation work must be in compliance with national and local plumbing codes and health department requirements. For standard water installation, connect per local plumbing codes. The drainage from the unit to the floor sink is achieved by gravity only. Make sure that the 1” white PVC tubing is directed downwards preventing any back-flow to the unit. Most local Health Departments require you to terminate the drainage tube 4 in. above the highest point of the fl...