Votos - 3, Puntuación media: 3
(
)
)
|
Resumen del manual
Service Top Load Washer Service Manual for Amana® This manual is to be used by qualified appliance technicians only. Amana does not assume any responsibility for property damage or personal injury for improper service procedures done by an unqualified person. RS3100007 Revision 0 October 1999 Table of Contents Important Information ................................................... 3 Important Safety Information ........................................ 4 General Information Proper Grounding and Polarization of 120 Volts Wall Outlets............................................ 5 Grounding Instructions .............................................. 5 General Operation Definition..................................... 6 Component Testing Information ................................... 7 Internal Motor Diagram and Schematic ........................ 9 Troubleshooting Procedures No hot water. ........................................................... 12 No cold water. ......................................................... 12 No warm water. ....................................................... 12 Water fill does not stop at proper level. ................... 13 Timer does not advance.......................................... 13 Motor does not operate. .......................................... 13 Washer smokes, overheats, and cycles on protector or switch actuator kicks in and out........ 14 No agitation. ............................................................ 14 Constant agitation. .................................................. 14 Slow spin or no spin. ............................................... 15 Constant spin. ......................................................... 15 Washer stops in middle of cycle or quits after a couple loads–intermittent. ................................. 15 Washer locks-up or binding. ................................... 16 Outer tub does not empty. ....................................... 16 Excessive vibration. ................................................ 16 Water leaking from outer tub................................... 16 Disassembly Procedures Control Hood Assembly .......................................... 17 Control Hood End Panels ........................................ 17 Electronic Control.................................................... 17 Timer ....................................................................... 17 Temperature and Speed Switch .............................. 18 Pressure Switch ...................................................... 19 Rocker Switch ......................................................... 19 Graphic Panel ......................................................... 19 Loading Door .......................................................... 19 Agitator.................................................................... 20 Agitator, Drive Bell and Seal Assembly ................... 20 Installing Drive Bell.................................................. 21 Service Access Panel ............................................. 22 Front Panel ............................................................. 22 Motor and Mounting Bracket ................................... 22 Pump and Belt Removal ......................................... 23 Reassembly of Pump and Belt ................................ 23 Motor Disassembly ................................................. 24 Idler lever and Pulley ............................................... 24 Motor Drive Belt ...................................................... 24 Motor Switch ........................................................... 24 Cabinet Top ............................................................. 25 Door Switch ............................................................. 25 Mixing Valve ............................................................ 25 Tub Cover and Gasket ............................................ 26 Washtub and Balance Ring..................................... 26 Outer Tub ................................................................ 26 Drive Pulley, Helix and Brake .................................. 27 Weldment and Bearing Assembly ........................... 28 Transmission Assembly .......................................... 29 Upper Bearing Assembly ........................................ 29 Friction Ring ............................................................ 29 Appendix A Installation Instructions (New Graphics).................A-2 Appendix B Owner's Manual (New Graphics) ........................... B-2 Appendix C Owner's Manual (Old Graphics).............................C-2 Amana Appliances Inc. • 2800 220thTrail • Amana, Iowa • 52204 • Printed in the U.S.A. RS3100007 Rev. 0 2 Important Information Pride and workmanship go into every product to provide our customers with quality products. It is possible, however, that during its lifetime a product may require service. Products should be serviced only by a qualified service techni...